MK1 Rabbit Engine
VolkswagenOwnersClub.com is the premier Volkswagen Forum on the internet. Registered Users do not see the above ads.
  1. Announcement:
    VWOC Rules Of Conduct
    kennix (Founder | ADMIN - VWOC)
    11-26-2009
    Views:
    76,398
+ Post New Thread
Page 1 of 3 1 2 3 LastLast
Threads 1 to 35 of 94

Forum: MK1 Rabbit Engine

Engine DIY

  1.   Sticky Threads  

  2. Sticky Thread Sticky: How I change out my Water Pump

    Changing a water pump? Don't work at it from the bottom up.... Try this. O dear, my water pump is nicht sie pumpin. it is gerfunked beyond...

    Started by briano1234, 08-26-2010 07:44 PM
    body, break, car, change, fan, faster, fluid, forum, gear, golf, jetta, loose, mount, paint, pulley, remove, removing, res, rust, spray, start, steering, support, volkswagen, work
    • Replies: 6
    • Views: 33,107
    01-08-2014 02:28 PM Go to last post
  3. Sticky Thread Sticky: How-to-flush-your radiator

    This is one of the best things that you can do for your car. Flushing out the old and renewing is a good thing. First lets get the old out and...

    Started by briano1234, 07-18-2010 03:42 PM
    buy, car, check, clear, cover, drive, engine, flush, good, heater, lip, lower, mount, power, remove, removing, replacement, res, ser, steering, things, time, top, watch, water
    • Replies: 18
    • Views: 28,036
    06-09-2013 10:48 PM Go to last post
  4. Sticky Thread Sticky: Replacing Head gasket Tip...

    I have read that many head gasket issues are the result of the head gasket moving during head replacement. This could be very true because we read...

    Started by amesghali, 03-07-2011 12:19 AM
    bolts, coolant, cut, driver, flat, guide, hand, head, head gasket, issues, job, moving, oil, people, read, remove, removing, replacement, screw, square, time, tip, tool, true, wheel
    • Replies: 12
    • Views: 29,205
    02-13-2013 08:53 AM Go to last post
  5. Sticky Thread Sticky: How to Replace your Valve Cover Gasket. 90-93 Cabby.

    How to remove and replace Valve cover Gasket 90-93 cabby Automatic shown no Cruise. The Better Gasket is from Victor-Reinz It is for a 1990 VW...

    Started by briano1234, 04-29-2011 06:29 PM
    air, automatic, cheap, cleaner, cover, cruise, driver, end, fan, foo, forced, forum, front, good, intake, mini, oil, parts, remove, removing, starting, sway bar, top, upgrade, volkswagen
    • Replies: 6
    • Views: 15,099
    01-10-2013 07:59 PM Go to last post
  6. Sticky Thread Sticky: Head bolt headache!!

    Ok, I need some help here before I go postal. I have had too many probs getting head bolts for my bunny. I ordered what the parts store said would...

    Started by DirtNap, 04-14-2012 02:33 PM
    1981, 4 door, big, bolt, bunny, custom, door, fit, forum, forums, great, head, heard, hey, long, ordered, parts, rabbit, set, style, thread, times, vin, volkswagen, vw rabbit
    • Replies: 5
    • Views: 3,061
    12-05-2012 11:52 PM Go to last post
  7.   Normal Threads  

  1. Unhappy 84 Rabbit - Low compression?

    Think I found the culprit...at least the primary contributor...to Bugs' being acutely obstinate regarding merely starting when its 30-40 deg outside....

    Started by RuralTowner, 12-01-2015 09:07 PM
    4 Pages
    1 2 3 4
    • Replies: 69
    • Views: 4,088
    10-29-2016 05:34 AM Go to last post
  2. Moved: Engne swap or Original?

    Started by exhilir, 10-19-2016 02:18 AM
    • Replies: -
    • Views: -
    10-19-2016 02:18 AM Go to last post
  3. Valve cover stripped bolts

    My 1.9 aaz mtr has one of the bolt holes for the valve cover on the head stripped out. What have others done to fix this.

    Started by Blue Haze, 09-21-2016 11:10 PM
    bolt, bolts, coil, cover, die, fix, head, head gasket, how to, larger, left, meat, mod, real, remember, repair, ripped, ser, shows, size, stripped, thread, tps, type, valve
    • Replies: 6
    • Views: 463
    09-24-2016 08:03 PM Go to last post
  4. 1.6d pump onto 1.9tdi

    Does anyone know if it is possible to take a mechanical pump and put it on a 1.9td I know you can put a 1.9td I head on a 1.6d but what about the...

    Started by slowbunny83, 09-19-2016 10:52 PM
    • Replies: 0
    • Views: 259
    09-19-2016 10:52 PM Go to last post
  5. no start no click

    83 1.7 rabbit conv gas, i installed new starter 4 months ago and yesterday morning she didnt start, no click from starter or anything, battery is...

    Started by 781rabbid83, 09-14-2016 05:49 PM
    ago, art, battery, click, conv, driver, forum, forums, gas, ins, installed, interior, key, months, morning, position, rabbit, relay, replaced, star, start, starter, switch, volkswagen, vw rabbit
    • Replies: 3
    • Views: 339
    09-16-2016 09:56 PM Go to last post
  6. Should I still drill a hole in this thermostat? If so, where?

    https://i.sli.mg/iixn0Z.jpg Thanks!

    Started by shornber, 06-13-2016 10:12 PM
    air, bubbles, cap, choice, don, drilling, edge, engine, fan, fluid, hole, hot, leave, lip, photobucket, replace, res, run, running, thermostat, times, top, tps, water, work
    • Replies: 2
    • Views: 526
    06-15-2016 07:22 AM Go to last post
  7. Remove A/C L-bracket from 84 Rabbit

    I'm in the process of replacing my water pump and the A/C unit is the next thing to come out. Then I can get after the alternator and then hopefully...

    Started by shornber, 06-10-2016 07:24 AM
    advice, album, alternator, attack, bolts, bracket, forum, forums, keeping, photo, process, pump, rabbit, remove, replacing, suggestions, thing, tps, uni, unit, volkswagen, vw rabbit, water, water pump, wha
    • Replies: 4
    • Views: 607
    06-13-2016 07:10 AM Go to last post
  8. Radiator return upgrade.

    I got tired of that Return hose weeping, or breaking, and every time that I have to take it off pray that I don't cut it off or break the radiator....

    Started by briano1234, 06-12-2016 07:51 PM
    1980, 98, albums, breaking, briano, cha, change, clamps, cut, degree, don, fit, fitting, hose, media, photobucket, radiator, return, time, tired, upgrade, user
    • Replies: 0
    • Views: 351
    06-12-2016 07:51 PM Go to last post
  9. Moved: 1984 cabby wont hold charge on battery?

    Started by outdoorcitizen, 06-05-2016 12:07 AM
    • Replies: -
    • Views: -
    06-05-2016 12:07 AM Go to last post
  10. Moved: Cabby go down at 100 km/h

    Started by AndreaPelle, 05-30-2016 03:45 AM
    • Replies: -
    • Views: -
    05-30-2016 03:45 AM Go to last post
  11. mk1 1.6 na into turbo diesel

    Hey does anyone know what kind of power gains i could get out of a 1.6 na with a td injector pump, td injectors, 1.9 head, 8v exhaust, t3/t4 turbo at...

    Started by slowbunny83, 05-05-2016 09:52 PM
    1.6, 1.9, boost, diesel, exhaust, gains, head, hey, injector, injector pump, injectors, kind, mk1, power, pump, turbo, turbo diesel, volkswagen, wha, wi
    • Replies: 0
    • Views: 353
    05-05-2016 09:52 PM Go to last post
  12. Moved: mk1 diesel performance

    Started by slowbunny83, 05-04-2016 07:15 PM
    • Replies: -
    • Views: -
    05-04-2016 07:15 PM Go to last post
  13. Moved: How huch does your diesel smoke?

    Started by russman, 04-23-2016 10:29 AM
    • Replies: -
    • Views: -
    04-23-2016 10:29 AM Go to last post
  14. Moved: Have a problem!

    Started by Zachkirk1221, 04-15-2016 11:31 PM
    • Replies: -
    • Views: -
    04-15-2016 11:31 PM Go to last post
  15. Moved: Leads for Muffler choices

    Started by 781rabbid83, 03-26-2016 12:45 AM
    • Replies: -
    • Views: -
    03-26-2016 12:45 AM Go to last post
  16. glow plug #2

    so i got out all the glow plugs and installed #'s 1 , 3, & 4 (from left to right) without too much trouble. #2 on the other hand seems impossible to...

    Started by xlthlx, 01-28-2016 09:26 AM
    's, allowed, bet, clearance, end, glow, glow plug, glow plugs, hand, hole, ideas, impossible, injector, injector pump, ins, installed, issue, left, plug, plugs, poster, posts, pump, trouble, wi
    • Replies: 1
    • Views: 450
    01-28-2016 10:05 AM Go to last post
  17. Moved: Engine turns but wont start, fuel filter maybe?

    Started by Ramblo, 01-08-2016 11:37 PM
    • Replies: -
    • Views: -
    01-08-2016 11:37 PM Go to last post
  18. Upgrading from a 1.8 oil pump to a 2.0 36mm pump.

    Due to a flaky intermittent low oil pressure light at idle when the temp was at 110 degrees I decided to upgrade my oil pump. I checked the oil...

    Started by briano1234, 12-31-2015 07:42 AM
    breaking, car, cheap, correct, green, idle, impression, installed, issue, light, low, lower, oil, oil pressure, ordered, pickup, pressure, removed, rpm, spec, tray, tube, upgrade, upgrading, valve
    • Replies: 0
    • Views: 469
    12-31-2015 07:42 AM Go to last post
  19. Engine randomly shuts off

    Hey guys, So the 85 cabriolet had been running great until a few days ago. Drove multiple miles with zero problems. Now, when i and im drive...

    Started by schuhk, 10-25-2015 12:56 AM
    brakes, braking, cabriolet, cold, days, die, drive, engine, great, ground, guys, hey, hit, hot, ice, idle, issue, lot, miles, owner, pics, power, problems, running, thinking
    • Replies: 4
    • Views: 896
    10-25-2015 10:56 AM Go to last post
  20. stuck injector heat shield

    I pulled my injectors for a rebuild but one of the heat shields is stuck fast... two popped out with ease, one fought be a little but the last one is...

    Started by russman, 10-11-2015 06:22 PM
    advice, coming, damage, edge, expe, expensive, fast, hard, heat, heat shield, hit, injector, injectors, las, lit, make, pin, popped, pulled, rebuild, round, shield, stuck, wi
    • Replies: 9
    • Views: 892
    10-19-2015 08:11 PM Go to last post
  21. V-Belt length w/o AC but with AC pulley on w/p

    Hello, I tried searching for a bit, so i thought i would post. I recently found my AC compressor was bad and pulled it, along with all hoses and...

    Started by schuhk, 10-08-2015 09:17 AM
    alternator, bad, belt, bit, cabriolet, compressor, crank, hey, ion, length, pos, post, pulley, pulleys, pump, ques, question, run, searching, ser, setup, thought, water, wha, work
    • Replies: 6
    • Views: 662
    10-16-2015 02:01 PM Go to last post
  22. 81 diesel rabbit wont start

    Hey, recently joined too see about getting some help with my 81 diesel rabbit pickup. I drove my rabbit all last summer, but I let it set all winter...

    Started by urfer183, 08-18-2015 12:26 AM
    • Replies: 2
    • Views: 862
    08-18-2015 01:57 PM Go to last post
  23. 1.6 Diesel injection pump timing and idle speed

    What effect does retarding or advancing the IP timing have on a diesel engine? Bentley says my standard IP timing should be "checking .83 -...

    Started by RabbitGabe, 08-16-2015 07:18 PM
    adjusting, bentley, car, cheap, diesel, don, engine, gauge, good, idle, injection, interior, low, number, performance, pump, question, rpm, running, set, speed, spray, standard, timing, volkswagen
    • Replies: 3
    • Views: 973
    08-16-2015 09:28 PM Go to last post
  24. 1981 Rabbit 1.6 Diesel driver side mount question. Thanks!

    Hello everyone! Not sure if the pics worked, but I have a question. I'm replacing the driver side mount, and I noticed that the bolt passes through...

    Started by RabbitGabe, 08-06-2015 12:13 AM
    • Replies: 13
    • Views: 1,006
    08-11-2015 09:56 AM Go to last post
  25. Checking Head Block for Warpage

    Blew the head gasket in the 84' Rabbit diesel the other day. Checked for any kind of warp-age long wise & found I can stick a .008 in - .010...

    Started by Rocfreya, 08-01-2015 11:47 AM
    bad, center, day, dead, diesel, engine, exhaust, forum, forums, gasket, gauge, head, head gasket, hey, kind, long, machined, manifold, rabbit, shop, start, step, stick, volkswagen, vw rabbit
    • Replies: 5
    • Views: 737
    08-02-2015 01:10 PM Go to last post
  26. Adjustment after Injection Pump Rebuild

    Are there any adjustments needed to be made to the IP after a finished rebuild? Believe its IP timing The sprocket position with the locking...

    Started by Rocfreya, 03-19-2015 02:13 PM
    • Replies: 1
    • Views: 721
    08-01-2015 01:28 PM Go to last post
  27. Rabbit New Fuel pump - engine not starting

    Working on a friends 81 Rabbit Pickup. Got a 16v Scrocco engine in it. Changed the fuel pump that's directly after the tank, & can verify its...

    Started by Rocfreya, 07-30-2015 09:59 AM
    air, alot, bleed, engine, forum, forums, friends, fuel, fuel pump, ins, pickup, pump, pushing, rabbit, run, running, star, starting, stay, tank, time, volkswagen, vw rabbit, working
    • Replies: 3
    • Views: 754
    08-01-2015 11:51 AM Go to last post
  28. 1981 Rabbit Diesel 1.6 motor mounts help

    Greetings everyone! My name is Gabe and I am brand new to the forum. Three years ago I inherited a 1981 Rabbit Diesel with the 1.6 n/a engine, 5...

    Started by RabbitGabe, 08-01-2015 12:41 AM
    1981, 5 speed, 81, car, classic, cover, diesel, engine, florida, forum, fuel, idle, injector pump, manual, mk1, motor, mounts, pics, rabbit, road, volkswagen, vw rabbit, wanted
    • Replies: 1
    • Views: 526
    08-01-2015 09:40 AM Go to last post
  29. Need New Radiator

    Hey guys, Im new here and this is my first post. Heres some background on the Rabbit. its a 78 1.5 diesel that I got for a really good deal. I just...

    Started by Legan, 06-21-2015 10:56 PM
    air, bad, california, car, deal, diesel, forum, fuel, fuel pump, good, guys, hey, long, makes, post, problem, rabbit, replacement, running, thinking, time, upgrade, volkswagen, vw rabbit, work
    • Replies: 17
    • Views: 1,496
    07-06-2015 09:16 PM Go to last post
  30. 1.6L Rabbit Diesel Vacuum pump not creating vacuum

    Hi everyone, I have a 82 rabbit caddy diesel and I'm having issues with the vacuum pump. Last winter I rebuilt my old pump and it worked for...

    Started by carroot1, 05-28-2015 04:55 PM
    bra, brand, break, create, day, diesel, end, engine, fine, forum, forums, gear, inside, installed, issues, line, making, pump, rabbit, truck, volkswagen, vw rabbit, win, winter, worked
    • Replies: 1
    • Views: 665
    05-28-2015 08:06 PM Go to last post
  31. Need Short Water Pump

    I have an 81 Rabbit Convertible 1.6L gas that I'm putting back together. It had had the AC butchered off of it at some time previously and the...

    Started by threedoor, 05-19-2015 01:17 PM
    auto, cabriolet, car, convertible, diesel, fixed, forum, forums, gas, harness, hey, hub, long, make, mile, rabbit, rock, short, suggestions, time, volkswagen, vw rabbit, waste, water, wiring
    • Replies: 1
    • Views: 549
    05-20-2015 10:12 PM Go to last post
  32. CIS Prostart guide

    http://chris.chemidl.in/cis-injection-hot-start-protraining-manual/

    Started by briano1234, 05-10-2015 04:17 PM
    art, chris, cis, guide, hot, injection, ion, manual, pro, pros, star, start
    • Replies: 0
    • Views: 695
    05-10-2015 04:17 PM Go to last post
  33. 1.6TD T3 weird turbo noise

    I just recently bought a caddy with a 1.6TD. The turbo was leaking really bad, so I took it out and rebuilt it. Now it spools much better and I can...

    Started by orb95, 05-04-2015 08:34 PM
    art, bad, bet, bought, caddy, cold, driving, hear, ideas, leaking, makes, minutes, motor, noise, normal, oil, oil pressure, pressure, sound, star, start, turbo, weird, whistle, whistling
    • Replies: 0
    • Views: 632
    05-04-2015 08:34 PM Go to last post
  34. Digifant Single Fuel pump conversion additions.

    Digifant Single Fuel Pump Conversion additions.

    Started by briano1234, 04-25-2015 09:10 AM
    93, additions, big, conversion, forums, fuel, fuel pump, pump, show, single, version, vwvortex
    • Replies: 0
    • Views: 830
    04-25-2015 09:10 AM Go to last post
  35. 200psi compression

    Just put the head back on with new gasket, hoping that was all. Did a compression test & only getting around 200psi in all cylinders. Now I'm...

    Started by Rocfreya, 03-08-2015 05:02 PM
    back, bot, bottom, cam, compression, diesel, dry, engine, exhaust, florida, gas, gasket, gauge, half, head, low, psi, rebuild, stuff, tearing, test, timing, tom, volkswagen, wi
    • Replies: 12
    • Views: 1,174
    03-19-2015 12:15 AM Go to last post

+ Post New Thread
Page 1 of 3 1 2 3 LastLast

Forum Information and Options

Users Browsing this Forum

There are currently 8 users browsing this forum. (0 members & 8 guests)

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 50 replies or 150 views
Hot thread with unread posts
More than 50 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
Volkswagen Forum Diminished Value of Oregon portland oregon seo DiminishedValue.net total loss value Privacy Policy
 

Vendor Tools vBulletin Plugins by Drive Thru Online, Inc.