Volkswagen Owners Club | VW Forum - DIY MKV Rabbit Rear Brakes - GTI Brake swap.
VolkswagenOwnersClub.com is the premier Volkswagen All Forum on the internet. Registered Users do not see the above ads.
  • What's New...

    BluGTI-188082

    Dash Dilema - Finish Installation of the Cabbie Dash in my Mk1 GTI?

    Thread Starter: BluGTI

    Hey Folks, Need a sense check on the project on which I am about to embark... My 84 GTI had a cabbie dash installed. The speedo, tach, fuel...

    BluGTI Yesterday, 10:54 PM Go to last post
    briano1234-6933

    1.9td AAZ head on 1.6na Questions

    Thread Starter: Lucassayers7

    Good evening, The head I would be getting only has seats and valve guides. I have found the intake and exhaust valves from parts place inc. which...

    briano1234 Today, 07:22 AM Go to last post
    2013Tdi-194905

    Wheel and try advice please

    Thread Starter: badman

    Hi All, Ive got 8 x 19 Et41 on my CC at the moment with 235/35/19 tyres can I use 8 x 19 Et26 with 235/40/19 tyres? any advice how I could make...

    2013Tdi Today, 04:21 AM Go to last post
    Haggie-183185

    Help deciding on tiguan...

    Thread Starter: stoff

    I'm debating buying a Tiguan, and the very existence of this forum makes me want to join your club. Here's my debacle. Tiguan #1 - 2011, 57,000...

    Haggie Yesterday, 10:22 AM Go to last post
    misdee21-191634

    2017 Beetle - Pale Grey ??!!!

    Thread Starter: misdee21

    Received my new 1.2 Beetle Design on a trailer yesterday - bought through an agent . Because it was so new , I was not able to see a paint chart...

    misdee21 Yesterday, 04:35 PM Go to last post
  • DIY MKV Rabbit Rear Brakes - GTI Brake swap.

    Why swap? The GTI utilizes 286mm rear rotors (solid), just 2mm smaller than the rabbit front rotors (288mm vented). Everyone has heard about the quick wear on the Rabbit rear brakes. However, the GTI's do not appear to have this problem. So at the cost of a few extra unsprung pounds you get longer brake pad/rotor life and shorter braking. Just like the front brakes the GTI and Rabbits share the same pads and calipers, the only difference being the rotor and caliper carriers.

    Difficulty rating 4/10 If you have the right tools its fairly simple.

    A couple of things to note.
    You cannot remove the rear calipers with the ebrake on. Use wheel chocks to stop the front wheels from moving and leave the car in 1st gear (manual) or park (automatic).
    You'll only need to do about 1/2 of what is shown if you are swapping the stock rotors/pads for a rabbit.

    Rotor Comparison (Rabbit rotor weight 9.0lbs GTI rotor weight 10.5lbs)


    Carrier Comparison (GTI's are in black at 1.5lbs, Rabbits in silver at 2lbs)



    Tools required.

    Jack
    14mm Triple Square
    3/8 in drive breaker bar
    T30 bit
    17mm deep weld socket and appropriate ratchet
    caliper piston compressor kit
    $99 tool rental at Advanced Auto Parts(fully refundable)
    $55 tool rental at Autozone (fully refundable)
    $20 (not including tax/shipping) to purchase from Harbor Freight (larger kit is $35)

    My final price from Harbor Freight was $30.40

    GTI swap additional tools
    13mm socket w/ ratchet
    15mm box/open end wrench
    tin snips

    I'm starting this off easy by breaking the torque on the lug nuts, jacking up the rear control arm then removing the wheel/tire.


    Locate the 14mm triple square bolts.


    Curse the skies in anger when the torque finally breaks and you rack your knuckles.

    Loosen bottom bolt.


    Remove top and bottom 14mm triple square bolt and wiggle caliper loose. (Note, you cannot remove the caliper with the ebrake on.)


    brace the caliper on something so as not to put any undue stress on the brake lines.


    To view the entire thread, Please go here:http://volkswagenownersclub.com/vw/s...GTI-Brake-swap.
    This article was originally published in forum thread: DIY MKV Rabbit Rear Brakes - GTI Brake swap. started by kiserhd View original post
  • Top 5 Posters This Week


    2013Tdi
    Guru Member
    Posts: 10

    misdee21
    3

    BluGTI
    3

    Cgrims
    3

    Lucassayers7
    1

  • Last 100 Visitors Map

    ZIP Code Maps
  • Facebook Fanpage

  • February VWOC Magazine

  • Disclaimer

    VolkswagenOwnersClub.com is an independent media publication. VolkswagenOwnersClub.com and its owners are not affiliated with or endorsed by Volkswagen AG or Volkswagen of America, Inc.
    Volkswagen is a registered trademark of Volkswagen AG.
    All rights reserved. All information Copyright 2006-2010

    Portland VW Dealers
Volkswagen Forum Diminished Value of Oregon portland oregon seo DiminishedValue.net total loss value Privacy Policy